Seagate FireCuda 540 Gen5 SSD review: Great real-world chops, and peace of mind

Best Prices Today: Seagate FireCuda 540 NVMe SSD

$179.99

You know the PCIe 5.0 NVMe market is picking up when venerable storage vendor Seagate enters the fray. The company’s new FireCuda 540 leverages the fifth-gen bus to turn in outstanding real-world performance.

It wasn’t quite the measure of the Crucial T700 in other tests, but it was close and is also a bit more affordable.

Further reading: See our roundup of the best SSDs to learn about competing products.

Seagate FireCuda 540 specs and design

The 540 is a 2280 (22mm wide, 80mm long) M.2 type utilizing four lanes of PCIe 5.0 for transfers. The NAND is Micron’s B58R 232-layer TLC, and the controller is Phison’s PS5026-E26. It’s double-sided, but still thin enough to upgrade most laptops.

The 540 is currently available in 1TB/$189.99 and 2TB/$319.99 flavors, putting it at the high end of the market, albeit a tad cheaper than Crucial’s top-rated T700 in a 2TB capacity. Note that some of the prices on Amazon at the time of this writing were ridiculously higher than that, so….

Fair warning. Before official pricing is announced, some unscrupulous online vendors charge far more than retail to take advantage of the over-anxious. Hold onto your horses and wait for real pricing from the vendor to show up before you buy any computer component.

Jon L. Jacobi

Seagate warranties the drive for five years and at 1TBW (terabytes written to the drive) for every terabyte of capacity. That’s a very generous TBW rating, and the company also provides data rescue for three years should something monstrously evil befall the drive. Note that SSDs are now so reliable, we’ve almost forgotten what failure is like.

How does the Seagate FireCuda 540 perform?

The 540’s performance was one of the best we’ve seen, but a mixed bag with extreme highlights and a couple of “low” points. The good news is that the drive set a record in our 48GB transfers, blasting its way past the previous record holder—the PCIe 4.0, host memory bus WD SN580. It also easily bested both of the PCIe 5.0 SSDs we’ve tested: the Gigabyte Aorus Gen5 10,000 and aforementioned Crucial T700.

The WD SN580 is included in these charts because of its stellar 48GB transfer performance, and the fact that it’s about a third the cost of the others.

Jon L. Jacobi

The “low” points were that FireCuda 540 lost to both PCIe 5.0 competitors by a hair in the synthetic benchmarks (CrystalDiskMark 8 and AS SSD 2.0) and lagged considerably behind them in the 450GB write. Of course, those fifth-gen competitors were both 2TB drives, while Seagate sent us the 1TB version of the 540. That means less secondary cache and slower times in that test.

Jon L. Jacobi

The FireCuda also behaved a bit oddly during the 450GB write. Normally, we see the top speed sustained until the secondary cache runs out, then a drop to the NAND’s native write speed (usually 250Mbps to 450Mbps). The 540 on the other hand started out at top speed (over 3GBps), then about a quarter of the way in dropped to around 1.7GBps and stayed there until the write was completed.

The overall time was acceptable in the grand scheme, but not on par for fifth-gen, with the aforementioned caveat concerning capacity.

Jon L. Jacobi

The only other facet of the FireCuda 540’s performance worth mentioning is that it was just a bit slow formatting. As you’ll likely only do this once (we reformat continually during testing), that’s not something you should ever worry about.

Should I buy the Seagate FireCuda 540?

The FireCuda 540’s real-world performance with the 48GB transfers bodes well for the average user, and it’s a bit cheaper in its 2TB incarnation than the Crucial T700. The outstanding TBW rating and data recovery make it a good fit for the average user with a PCIe 5.0 M.2 slot.

However, I’d be remiss if I didn’t inform you that you can get almost the same real-world performance for far, far less. Some of the latest HMB PCIe 4.0 designs such as the WD Blue SN580 listed in the charts or the Sabrent Rocket Q4 are also very fast at our 48GB transfers. Again, the former is less than one-third the price of the FireCuda 540.

How we test

Internal drive tests currently utilize Windows 11, 64-bit running on an X790 (PCIe 4.0/5.0) motherboard/i5-12400 CPU combo with two Kingston Fury 32GB DDR5 4800MHz modules (64GB of memory total). Both 20Gbps USB and Thunderbolt 4 are integrated to the back panel and Intel CPU/GPU graphics are used. The 48GB transfer tests utilize an ImDisk RAM disk taking up 58GB of the 64GB of total memory. The 450GB file is transferred from a Samsung 990 Pro 2TB which also runs the OS.

Each test is performed on a newly formatted and TRIM’d drive so the results are optimal. Note that in normal use, as a drive fills up, performance will decrease due to less NAND for secondary caching, as well as other factors.

Caveat: The performance numbers shown apply only to the drive we were shipped and to the capacity tested. SSD performance can and will vary by capacity due to more or fewer chips to shotgun reads/writes across and the amount of NAND available for secondary caching. Vendors also occasionally swap components. If you ever notice a large discrepancy between the performance you experience and that which we report, by all means, let us know.